运载火箭结构动力学模拟技术研究进展

潘忠文; 曾耀祥; 廉永正; 邢誉峰

doi:10.6052/1000-0992-12-063

运载火箭结构动力学模拟技术研究进展

doi: 10.6052/1000-0992-12-063

1 北京宇航系统工程研究所, 北京 100076
2 北京航空航天大学固体力学研究所, 北京 100191

基金项目: 总装备部十一五预研项目(51320103), 航天支撑项目(618010604-02), 国防“973” 项目(613133) 资助

详细信息

通讯作者:
潘忠文

计量
- 文章访问数: 1937
- HTML全文浏览量: 143
- PDF下载量: 2329
- 被引次数: 0
出版历程
- 收稿日期: 2012-03-20
- 修回日期: 2015-05-31
- 刊出日期: 2012-07-25

REVIEWS IN STRUCTURAL DYNAMICS ANALOGY TECHNIQUE OF LAUNCH VEHICLE

1 Beijing Institute of Astronautical System Engineering , Beijing 100076, China
2 The Solid Mechanics Institute, Beihang University, Beijing 100191, China

Funds: The project was supported by the Eleventh Five General Armament Department Advanced Research Project (51320103), Space-Support Project (618010604-02) and 973 National Defense Project (613133).

More Information

Corresponding author: PAN Zhongwen

摘要

摘要: 本文首先按照火箭的不同型号, 综述了国内外全箭模态分析及试验验证的进展情况; 然后, 从蒙皮加筋圆柱壳结构动力学建模、液体推进剂动力学模拟、局部振型斜率预示三个方面, 综述了火箭动力学建模技术进展; 最后根据火箭动力学发展需求, 对后续研究提出了一些建议.
- 全箭模态 /
- 试验验证 /
- 板壳结构 /
- 推进剂 /
- 振型斜率
Abstract: First in this paper, based on different kinds of launch vehicles, domestic and overseas overall modal analysis and experiments verification are respectively reviewed. Then dynamics modeling techniques are respectively summarized from three directions, such as dynamics modeling of cylindrical shell- stiffened, dynamics simulation of liquid propellant, prediction methods of local mode shape-slope. Finally, further research directions are suggested based on the development needs of structural dynamics of launch vehicles.
- overall model /
- experiments verification /
- cylindrical shell-stiffened /
- liquid propellant /
- mode shapeslope

HTML全文

参考文献(81)

1 Alley V L JR, Leadbetter S A. Prediction and measurement of natural vibrations of multistage launch vehicles, AIAA Journal 1(2): 374-379

2 王毅, 朱礼文. 大型运载火箭动力学关键技术及其进展综述. 导弹与航天运载技术, 2000, (1): 29-37

3 邱吉宝. 航天器计算结构动力学研究情况展望. 导弹与航天运载技术, 1993, (4): 37-44

4 邱吉宝, 王建民. 运载火箭模态试验仿真技术研究新进展. 宇航学报, 2007, 28(3): 515-521

5 Leadbetter S A. Application of analysis and models to structural dynamic problems related to the apollo-saturn v launch vehicle. NASA TN D-5831, June 1970

6 王龙生, 张德文. 火箭结构有限元分析的若干问题. 强度与环境, 1988, (3): 45-53

7 Peele E L, Thompson W M, Jr, Pusey C G. A theoretical and experimental investigation of the three-dimensional vibration characteristics of a scaled model of an asymmetrical launch vehicle. NASA TN D-4707, August 1968

8 Catherines J J. Experimental vibration characteristics of a 1/40-scale dynamic model of the saturn V-launchumbilical- tower configuration. NASA TN D-4870, November1968

9 Adelman H M, Steeves E C. Vibration analysis of a1/40-scale dynamic model of saturn V-launch-platform- umbilical-tower configuration. NASA TN D-4871, November1968

10 Steeves E C, Catherines J J. Lateral vibration characteristics of a 1/40-scale dynamic model of the apollo-saturn V launch vehicle. NASA TN D-4872, 1968

11 Leadbetter S A, Raney J P. Model studies of the dynamics of launch vehicles. Journal of Spacecraft and Rockets,1966, (3): 936-938

12 Leadbetter S A, Leonard H W, Brock E J Jr. Design and fabrication considerations for a 1/10-scale replica model of the apollo/Saturu V. NASA TN D-4138, October 1967

13 Leadbetter S A, Leonard H W, Peele E L. Lateral Vibration Characteristics of the 1/10-scale Apollo/Saturn V Replica Model. NASA TN D-5778, April, 1970

14 Leadbetter S A. Application of analysis and models to structural dynamic problems related to the apollo-saturn V launch vehicle. NASA TN D-5831, June, 1970

15 Pinson L D, Leonard H W. Longitudinal vibration characteristics of 1/10-scale apollo/saturn V replica model. NASA TN D-5159, April, 1969

16 Peele E L, Leonard H W, Leadbetter S A. Lateral vibration characteristics of the 1/10-scale apollo/saturn V replica model. NASA TN D-5778, April, 1970

17 Grimes P J, McTigue L D, Riley G F, et al. Advancements in structural dynamic technology resulting from saturn V programs. Vol.I, NASA CR-1539, June, 1970

18 Grimes P J, McTigue L D, Riley G F, et al. Advancements in structural dynamic technology resulting from saturn V programs. Vol.II, NASA CR-1540, June, 1970

19 Thornton E A. Vibration analysis of a 1/15-scale dynamic model of a space shuttle configuration. NASA CR-111984,1972

20 Bernstein M, Mason P W, Zalesak J, et al. NASTRAN analysis of the 1/8-scale space shuttle dynamic model. NASTRAN: Users’ Experiences. NASA TM X-2893, September 1973. 169-241

21 Mason P W, Harris H G, Zalesak J, et al. Analytical and experimental investigation of a 1/8-scale dynamic model of the shuttle orbiter. Volume I - Summary Report. NASA CR-132488, May 1974; Volume II - Technical Report. NASA CR-132489, May, 1974

22 Bernstein M, Coppolino R, Zalesak J, et al. Development of technology for fluid-structure interaction modeling of a1/8-scaledynamic model of the shuttle external tank (ET). Volume I: Technical Report. NASA CR-132549, August,1974

23 Levy A, Zalesak J, Bernstein M, et al. Development of technology for modeling of a 1/8-scale dynamic model of the shuttle solid rocket booster (SRB). NASA CR-132492, July, 1974

24 Zalesak J. Modal coupling procedures adapted to nastran analysis of the 1/8-scale shuttle structural dynamics model. NASA CR-132666, July, 1975

25 Pinson L D. Coordinator: analytical and experimental vibration studies of a 1/8-scale shuttle orbiter. NASA TN D-7964, December, 1975

26 Leadbetter S A, Stephens W B, Sewall J L, et al. Vibration characteristics of 1/8-scale dynamic models of the space-shuttle solid-rocket boosters. NASA TN D-8158, May, 1976

27 Blanchard U J, Miserentino R, Leadbetter S A. Experimental investigation of the vibration characteristics of a model of an asymmetric multielement space shuttle. NASA TN D-8448, September, 1977

28 Pinson L D, Leadbetter S A. Some results from 1/8-Scale shuttle model vibration studies. Journal of Spacecraft and Rockets, 1979, 16: 48-55

29 Emero D H. The quarter-scale space shuttle design, fabrication, and test. AIAA, 1979-0727, 1979

30 Emero D H. Quarter-scale space shuttle design, fabrication and test. Journal of Spacecraft and Rockets, 1980, 8:303-310

31 Ralph D B, Justin D, Mercedes C R. TAres I-X flight test vehicle: stack 5 modal test, NASA/TM-2010-216183

32 Ralph D B, Ralph D B, Justin D. Ares I-X launch vehicle modal test overview. In: Proceedings of IMAC XXVIII, February 2010

33 Knight N F Jr, Phillips D R. Ares I-X upper stage simulator structural analyses supporting the nesc critical initialflaw size assessment. NASA/TM-2008-215336, NESCRP-08-09/06-081-E

34 Yoshiki M. 于海昌. 译. 1/5 缩尺H-II 运载火箭的振动试验. 导弹与航天运载技术, 1988, 2: 64-73

35 Yoshiki M. Vibration test of 1/5 H-II launch vehicle. AIAA-1987-0783, 1987

36 Claramonte M 著, 王晋桦. 译. 阿里安运载火箭的动态试验. 导弹与航天运载技术, 1981.8: 60-65

37 Bertram 著, 李庆忠. 译. 用扩充的模态鉴定试验验证阿里安

4 有效载荷整流罩数学模型. 导弹与航天运载技术, 1990.12:49-58

38 Barthe D, Romeuf T. 阿里安5 运载火箭的动力学模型. 《阿里安5 结构与环境文集》, 1996.12

39 于海昌, 朱礼文, 王明宇, 等. 大型捆绑火箭模态试验/分析的相关性研究. 导弹与航天运载技术, 1993, 2: 42-52

40 吴素春, 贾文成, 邱吉宝. 载人运载火箭全箭模态试验. 宇航学报, 2005, 26(5): 531-534

41 谭志勇, 王毅, 王明宇. 针对未来大运载火箭的缩比模型动特性仿真研究. 强度与环境, 2002, 29(4):11-18

42 邓魁英, 王毅. 火箭动特性的缩比模型及建模分析. 导弹与航天运载技术, 2003, 3: 6-12

43 王心清. 导弹与航天丛书结构设计. 北京: 宇航出版社,1994

44 Zhang L, Xiang Y. Vibration of open circular cylindrical shells with intermediate ring supports. Int. J. Solids Struct, 2006, 43: 3705-3722

45 Li X B. A new approach for free vibration analysis of thin circular cylindrical shell. J. Sound Vib, 2006, 296: 91-98

46 Pan Z, Li X B, Ma J J. A study on free vibration of a ring-stiffened thin circular cylindrical shell with arbitrary boundary conditions. J. Sound Vib, 2008, 314: 330-342

47 Wang C, Lai J C S. Prediction of natural frequencies of finite length circular cylindrical shells. Appl. Acoust, 2000,59: 385-400

48 ¨Omer C. Numerical analysis of free vibrations of laminated composite conical and cylindrical shells: Discrete singular convolution (DSC) approach. J. Comput. Appl. Math,2007, 205: 251-271

49 Lee Y S. A study on the free vibration of the joined cylindrical-spherical shell structures. Compos. Struct,2002: 2405-2414

50 Lee Y S, Choi M H. Free vibrations of circular cylindrical shells with an interior plate using the receptance method. J. Sound Vib, 2001, 248(3): 477-497

51 Naeem M N , Sharma C B. Prediction of natural frequencies for thin circular cylindrical shells. Proc Instn. Mech. Engrs, 2000, 214: 1313-1328

52 Pellicano F. Vibrations of circular cylindrical shells: Theory and experiments. J. Sound Vib, 2007, 303: 154-170

53 Qatu M S, Sullivan R W, Wang W. Recent research advances on the dynamic analysis of composite shells: 2000-2009. Compos. Struct, 2010, 93(1): 14-31

54 Wong S K, Sze K Y. Application of the matched asymptotic expansion to the free vibration of a hermetic shells. J. Sound Vib, 209(4): 593-607

55 邢誉峰, 潘忠文, 杨阳. 蒙皮加筋圆柱壳弯曲频率的三种计算模型. 北京航空航天大学学报, 2012, 38(4): 438-443

56 潘忠文, 邢誉峰, 杨阳. 蒙皮加筋圆柱壳扭转频率的三种计算模型. 北京航空航天大学学报, 2011, 37(9): 1156-1159

57 Abramson H N. The dynamic behavior of liquids in moving containers. NASA SP-106, 1966

58 赵人濂. 液体火箭推进剂晃动特性的结构控制. 宇航学报,1984, 1: 58-68

59 夏益林, 许婉丽. 椭球形贮箱内液体晃动特性试验研究. 宇航学报, 1991, 22(4): 70-76

60 尹立中, 航天工程中液体大幅晃动及贮箱类液固耦合动力学研究: [博士论文]. 哈尔滨: 哈尔滨工业大学, 1999.10-25

61 杨蔓, 李俊峰, 王天舒, 等. 带环形隔板的圆柱储箱内液体晃动阻尼分析. 力学学报, 2006, 38(5): 660-667

62 周宏, 李俊峰, 王天舒. 用于ALE 有限元模拟网格更新方法. 力学学报. 2008, 40(3): 266-272

63 Eric R C, Joseph B. Launch vehicle slosh and hydroelastic loads analysis using the boundary element method. AIAA, 1997-1036, 1997

64 Rubin S. Longitudinal instability of liquid rockets due to propulsion feedback (POGO). Journal of Spacecraft and Rockets,1966, 3(8): 1188-1195

65 Thompson W M, Jr. An investigation of the response of a scaled model of a liquid-propellant multistage launch vehicle to longitudinal excitation. NASA TN D-3975, 1967

66 Bohdan W O, Rubint S. Advanced pogo stability analysis for liquid rockets. Journal of Spacecraft and Rockets,1993, 30(3): 360-373

67 Anon. Prevention of coupled structure-propulsion instability (POGO). NASA Space Vehicle Design Criteria (Structures), NASA SP-8055, 1970

68 王其政, 张建华, 马道远. 捆绑液体火箭跷振(POGO) 稳定性分析. 强度与环境, 2006, 33(2): 6-11

69 任辉, 任革学, 荣克林. 液体火箭POGO 振动蓄压器非线性仿真研究. 强度与环境, 2006, 33(3): 1-6

70 司徒斌, 高普云. 低温运载火箭POGO 抑制系统研究. 低温工程, 2006(2): 58-64

71 Archer J S, Rubin C P. Improved analytic longitudinal response analysis for axisymmetric launch vehicles, volume I-linear analytic model. NASA CR-345, December 1965

72 Rubin C P, Wang T T. Improved analytic longitudinal response analysis for axisymmetric launch vehicles, vol. II -computer program description. NASA CR-346, 1965

73 Larry D P. Longitudinal spring constants for liquidpropellant tanks with ellipsoidal ends. NASA TN D-2220, November 1964

74 Pinson L D, Leonard H W, Raney J P. Analyses of the longitudinal dynamics of launch vehicles with application to a l/l0-scale saturn V model. Spacecraft Rockets, 1968,5(3): 303-308

75 龙乐豪. 导弹与航天丛书—— 总体设计(上册). 北京: 宇航出版社, 1989: 469-475

76 王建民, 荣克林, 冯颖川, 等. 捆绑火箭全箭动力学特性研究. 宇航学报, 2009, 30(3): 821-826

77 李道奎, 刘林, 万军. 牵制释放过程中火箭液体推进剂的建模研究. 强度与环境, 2008, 35(6): 14-18

78 Pan Z Q, Xing Y F, Zhu L W. Liquid propellant analogy technique in dynamic modeling of launch vehicle. Science China Technological Sciences, 2010, 53(8): 2102-2110

79 潘忠文, 王旭, 邢誉峰. 基于梁模型的火箭纵横扭一体化建模技术. 宇航学报, 2010, 40(8): 920-928

80 潘忠文. 运载火箭动力学建模及振型斜率预示技术. 中国科学, E 辑: 技术科学, 2009, (3): 469-473

施引文献

资源附件(0)

访问统计